HIGH QUALITY, HARD TO GET AND CUSTOM ELECTROLYTIC CAPACITORS FOR POWER SUPPLIES, DISPLAYS, TVs, MOTHERBOARDS AND MORE!

Differential-mode and common-mode EMI filter coils

Hardware Insights specializes in power supplies. In this part of the forum, you will find detailed information on every aspect of power supplies, including how to repair them and how to judge if a power supply is a good quality unit or not.

Differential-mode and common-mode EMI filter coils

Postby LongRunner » November 18th, 2013, 7:33 pm

There's a reason why they have both coils with only one winding, in one side of the mains (which reviews here refer to as "half" a coil), and those with two windings, one for each side of the mains (a "full" coil).

The ones in only one side of the mains are, along with X-class capacitors, for differential-mode (live-to-neutral) noise filtering. You can expect these to have an inductance of up to a few hundred microhenries (µH), which won't cause a significant voltage drop, even at 63Hz (semi-regularly given as the upper end of the frequency range, though most PSUs can probably go quite a bit higher without problems) and with several amps of current draw. The downside, however, is that they are not efficient at common-mode (between live/neutral and earth) noise filtering, as Y-class capacitors are by necessity much smaller than X-class, as current flow in the earth wire has to be limited to a safe level.

The ones with windings for each side of the mains are those used for common-mode noise filtering. One with a ferrite EE-25 core that I'm looking at right now, bearing the "Ever-power" branding as commonly seen in PSUs made by K-Mex, is rated for 13 millihenries. The reactance you'd get from putting a 13mH differential-mode inductor in series with the mains is:

2*pi*60*0.013 = 4.9Ω

Now obviously that would be a hell of a lot to put in line with the PSU input, as several volts would be dropped. That inductor would also have to have a very large core to avoid saturating under the load current.

Fortunately for PSU engineers, there's a trick that sidesteps both problems: Build an inductor with two windings on a common core, and wire it up so that the load current induces equal and opposite magnetic fields in each winding. These cancel each other out and result in zero net magnetic field, preventing saturation of the core. And because the field can no longer form (unless someone miswires the inductor or the PSU), the inductance as far as the load is concerned is 0mH. This does also mean that they are ineffective against differential-mode noise, but using both them and the differential-mode inductors in conjunction is still a win-win for cost and performance.
Information is far more fragile than the HDDs it's stored on. Being an afterthought is no excuse for a bad product.

My PC: Core i3 4130 on GA‑H87M‑D3H with GT640 OC 2GiB and 2 * 8GiB Kingston HyperX 1600MHz, Kingston SA400S37120G and WD3003FZEX‑00Z4SA0, Pioneer BDR‑209DBKS and Optiarc AD‑7200S, Seasonic G‑360, Chenbro PC31031, Linux Mint Cinnamon 20.3.
User avatar
LongRunner
Moderator
 
Posts: 1031
Joined: May 17th, 2013, 5:48 pm
Location: Albany, Western Australia

Return to POWER SUPPLIES!

Who is online

Users browsing this forum: No registered users and 35 guests